Lauda Air
Flight 004
was a scheduled international passenger flight from
Kai Tak
,
Hong Kong, China
to
Wien-Schwechat International Airport
,
Vienna
,
Austria
via
Don Mueang International Airport
,
Bangkok
,
Thailand
. On 26 May 1991, during it's Bangkok to Vienna leg, the
Boeing 767
-3Z9ER operating the route suffered from a rare uncommanded
thrust reverser
deployment while flying over the Burma-Thai border and crashed into wooded terrain about ~94 nautical miles northwest of Bangkok, killing all 213 passengers and 10 crew members on board. It is the first and deadliest loss involving the Boeing 767, and as of 2022, Thailand's worst aviation accident.
The positions of the left engine thrust reverser actuators along with data from the electronic engine control (EEC) and the cockpit voice recorder (CVR) indicate that the left engine thrust reverse system deployed while the airplane was at approximately .78 Mach (478 kn, 550 mph, 885 km/h), climbing through 24,700 feet to flight level 310. The preliminary evidence suggests that the reverse event was recognized by the flight crew, but that the airplane departed controlled flight.
The true cause of the activation of the reverser was never found because all of the wires and the Digital
Flight Data Recorder
were destroyed in the crash, but it was thought to be caused by a short circuit that opened both valves for a split second, allowing the reverser to activate.
Lauda Air Flight 004 took off from Runway 21L in Don Mueang at 23:02 PM
ICT
(4:02 PM UTC). The aircraft began a normal climb to an initial altitude of 7,000 feet, then was cleared to 11,000 feet by Bangkok Center. The flight followed a departure requiring a left turn upon leaving the airport. Shortly thereafter, Flight 004 was cleared to
FL
310 (flight level 310, or 31,000 feet). The aircraft carrying 213 passengers and 10 crew members.
5 minutes into the flight, the pilots received a master caution "REV ISLN VAL" advisory on the EICAS display, accompanied with the master caution tone. First Officer Thurner replied with an expletive. Captain Welch replied, "that keeps coming on". The crew discussed the issue as Thurner looked through the
quick reference handbook
for a solution, but the handbook then quoted "additional system failures may cause in-flight deployment", and to "expect normal reverser operation after landing". There was no further action required.
First Officer Thurner asked if he should contact the Lauda maintenance crew in Bangkok, and the captain reassured him, saying that it was "just an advisory thing", and that there was "just water, or moisture in there", and moved on; the first officer shortly thereafter tells the captain that the aircraft needs "a little bit of rudder trim to the left". Over the next few minutes, the aircraft continued on its filed flight plan while climbing to FL310.
At 23:17 PM ICT (4:17 PM UTC), some nine minutes after the master caution advisory, while climbing to FL310 as cleared, the left engine
thrust reverser
activated. Immediately after, the first officer acknowledged this, stating "Shit,
reverser
deployed," followed by loud bangs, snaps, and the sound of the overspeed siren. In just 4 seconds, the aircraft banked over 90 degrees to the left and began to descend as it shuddered with the aerodynamic forces. Captain Welch disconnected the
autopilot
(or it disconnected automatically because of the overbank) and takes manual control, which consisted of continuous sustained elevator nose up inputs. The aerodynamic stresses tore the tail section free of the aircraft, leaving it uncontrollable.
The loss of the tail provided extreme negative loading of the wings and sheared them clean of the aircraft, and the burning remains of Flight 004 crashed into wooded terrain in the Dan Chang District of Thailand at speeds of over
Mach 1
and burst into flames. There are no survivors. Shortly after the accident, local villagers began to loot the crash site.
The available recovery time for the crew to rectify the situation was 4 seconds. The crew never could have reacted fast enough to stop the accident.
Josef Thurner
, the copilot, once flew as a co-pilot with Niki Lauda on a Lauda Boeing 767 service to Bangkok, a flight that was the subject of a
Reader's Digest
article in January 1990 that depicted the airline positively. Macarthur Job stated that Thurner was the better known of the crew members.
[1]
Thomas J. Welch, the captain, lived in
Vienna
,
[2]
but originated from
Seattle
, Washington.
[3]
- ↑
Job, p. 204. "Of all the crew, Josef Thurner was perhaps the better known thanks to having been copilot to Niki Lauda himself on a Boeing 737 service to Bangkok which became the subject of a highly affirmative article on the airline and its history in the January 1990 issue of
Reader's Digest
[...]"
- ↑
Wallace, Charles P. "'All Evidence' in Thai Air Crash Points to Bomb".
Los Angeles Times
. 28 May 1991.
2
. Retrieved 15 February 2013.
- ↑
"
Pilots' Final Words
Archived
2014-07-29 at the
Wayback Machine
". Associated Press].
The Seattle Times
. 6 June 1991. Retrieved 15 February 2013.