Not to be confused with one of the aircraft featured in
Air Canada Flight 759
1998 aviation incident
On June 28, 1998,
United Airlines Flight 863
, a
Boeing 747-400
flying United's regularly scheduled transpacific service from
San Francisco Airport
to
Sydney Airport
was forced to shut down one of its right-wing engines and nearly collided with
San Bruno Mountain
while recovering from the engine failure. The aircraft was able to dump fuel over the Pacific Ocean and return to San Francisco for an overweight landing, but the occurrence prompted
United
to change pilot training requirements.
Flight
[
edit
]
Flight 863 to Sydney departed from
San Francisco International Airport
at 10:39 pm
PST
on Sunday June 28, 1998 (
UTC
: 5:39 am, 29 June).
[1]
As it took off, the
Boeing 747-400
entered fog at the end of runway 28R.
[2]
After lifting off, the crew experienced a "loud thumping noise" accompanied by vibration just after the aircraft's landing gear had retracted.
[2]
The first officer was handling the takeoff under the captain's supervision, and since the noise occurred just after the landing gear had been retracted, at approximately 300 feet (90 m) above ground level, the first officer initially believed one of the tires had failed.
[2]
At the same time, the exhaust gas temperature of the #3 engine (the inboard engine on the starboard wing) rose to 750 °C (1,380 °F), exceeding the takeoff limit of 650 °C (1,202 °F).
[2]
With the first officer still flying, the captain retarded the #3 engine throttle to idle, which stopped the temperature rise and aircraft vibration.
[2]
There were two non-flying relief pilots in the cockpit during takeoff; both noticed the aircraft had lost approximately 40
knots indicated airspeed
after the problems with #3 engine and shouted 'airspeed' to the first officer to alert him to the potential
stall
danger.
[2]
At that point, the
stick shaker
system activated and the captain took over control of the aircraft.
[2]
The captain later stated he held the aircraft level to gain airspeed and avoid a stall,
[2]
but it had drifted to the right due to the imbalanced thrust and narrowly missed colliding with San Bruno Mountain, which rises to a height of 1,319 feet (402 m) above sea level, excluding the television and radio towers on its summit.
According to the
cockpit voice and flight data recordings
, rather than using the rudder, the first officer had tried to compensate for the right drift by turning the aircraft to the left using ailerons, which control the aircraft's longitudinal "roll" axis rather than the vertical "yaw" axis which would have been the correct response to compensate for an asymmetrical thrust condition. The use of ailerons also deployed spoilers on the "down" wing, which increased the aircraft's net drag and decreased its net lift. A second activation of the stick shaker stall warning resulted.
[1]
[3]
The relief pilots urged the flight crew to enter a shallow dive to gain airspeed and avoid a stall,
[1]
[3]
but this soon brought the aircraft close to San Bruno Mountain. The
ground proximity warning system
then alerted the captain, who had since taken over flying the aircraft, to pull up to avoid striking the hill.
[3]
By later accounts, the plane narrowly cleared San Bruno Mountain by only 100 feet (30 m).
[1]
The aircraft had approached San Bruno Mountain so closely that air traffic control radars briefly stopped detecting the aircraft. An air traffic controller in the San Francisco tower was conversing with one of her colleagues and said, "... Is United 863 still ... oh there he is, he scared me, we lost radar, I didn't want to give you another airplane if we had a problem."
[1]
[4]
In total, the aircraft had disappeared from radar for approximately 15 seconds.
[5]
Residents in houses along the flight path, in South San Francisco, Daly City, and San Francisco, called into the airport to complain about the noise and voice their fears the aircraft was about to crash.
[1]
After the near-collision, UA863 was vectored out to sea to dump fuel to reduce weight and return to San Francisco for an overweight landing.
[2]
During the initial climbout, the first officer stated he had noted the aircraft was handling sluggishly and was slow to climb, which he instinctively responded to by "[pulling] the nose up just a bit more to climb away from the ground."
[2]
The first officer had limited experience, having made only one takeoff and landing in a 747 during the year preceding the occurrence.
[3]
Aftermath
[
edit
]
United revised its training protocols after the incident by implementing much more rigorous standards, which ultimately became industry-wide standards. All 9,500 of United's pilots were shown a recreation of the occurrence, filmed in one of United's simulators.
[3]
As a compromise, pilots were required to make at least three takeoffs and landings in a 90-day period, of which at least one had to be in an actual aircraft.
[1]
[3]
Aviation media consultant Barry Schiff noted the incident in an article decrying the lack of basic stick-and-rudder skills, especially among pilots who had never flown a
light aircraft
.
[6]
United still uses Flight 863 for its transpacific service from San Francisco to Sydney, but now using a
Boeing 777-300ER
.
[7]
References
[
edit
]
External links
[
edit
]
Aviation accidents and incidents in the United States and U.S. territories in the 1990s
|
---|
1990
| |
---|
1991
| |
---|
1992
| |
---|
1993
| |
---|
1994
| |
---|
1995
| |
---|
1996
| |
---|
1997
| |
---|
1998
| |
---|
1999
| |
---|
This list is incomplete.
|